Toyota Land Cruiser

FJ60, FJ62 and FJ80 1980-1997 of release

Repair and operation of the car



Toyota Land Cruiser
+ 1. Maintenance instruction
- 2. Maintenance
   2.1. Additional maintenance
   2.2. Technical characteristics
   2.3. An arrangement of units in a motor compartment
   2.4. Maintenance terms
   + 2.5. Check of level of liquids
   2.6. Check of a condition of tires and pressure in tires
   2.7. Liquid level in automatic transmission
   2.8. Liquid level in system of a hydraulic actuator of steering
   2.9. Replacement of oil in the engine and an oil filter
   2.10. Check of a state and care of the battery
   2.11. Check of the cooling system
   2.12. Check and replacement of hoses in a motor compartment
   2.13. Check and replacement of brushes of screenwash
   2.14. Shift of wheels
   2.15. Check of a suspension bracket and steering
   2.16. Check of the exhaust system
   2.17. Check of level of oil in the manual transmission
   2.18. Check of level of oil in the transfer case
   2.19. Check of level of oil in reducers of bridges
   2.20. Check of a condition of seat belts
   2.21. Thermostat of the air filter (carburetor engines)
   2.22. Check and lubricant of the exhaust valve
   2.23. System of catching of vapors of gasoline
   2.24. Check of system of recirculation
   2.25. Air gate of the carburetor
   2.26. Zolotnik of system of ventilation of a case
   2.27. Check and replacement of the air filter
   2.28. Replacement of spark plugs
   2.29. Check and adjustment of gaps of valves
   2.30. Idling turns (carburetor engines)
   2.31. Drive belts
   2.32. Check of fuel system
   + 2.33. Check of brakes
   2.34. Check and adjustment of pedals of coupling (brake)
   2.35. Replacement of the fuel filter
   2.36. High-voltage wires, runner and covers of the distributor
   2.37. Check and installation of the moment of ignition
   2.38. Care of the cooling system
   2.39. Naves and bearings of forward wheels
   2.40. Replacement of liquid in automatic transmission and the filter
   2.41. Replacement of oil in the manual transmission
   2.42. Replacement of oil in the transfer case
   2.43. Replacement of oil in a back (forward) reducer
   2.44. Gaps in valves on the engine 1FZ-FE
+ 3. Engines
+ 4. Cooling systems, heating
+ 5. Fuel and exhaust systems
+ 6. System of decrease in toxicity
+ 7. Transmission
+ 8. Brake system
+ 9. Suspension brackets and steering
+ 10. Body
+ 11. Electric equipment
+ 12. Electrical circuitries




eeac64fe


2.32. Check of fuel system

GENERAL INFORMATION

Prevention

When performing service of fuel system follow fire safety regulations. On cars with injector engines disconnect any hoses after performance of actions for a decompression.


It is the best of all to check fuel system when the car is raised by a telfer or is established on supports to provide access to details from the bottom.

If during driving or after the parking of the car under the sun the gasoline smell is felt, then the fuel system needs urgent careful check.

PERFORMANCE ORDER
1. Turn off a stopper of a jellied mouth of the fuel tank and check on it existence of traces of corrosion and damage of laying. If necessary replace a stopper.
2. Check, being under the car, a condition of a tank and a pipe of a mouth. Especially attentively examine connection of a mouth with a tank. Existence of punctures, cracks and mechanical damages is not allowed.
3. Carefully examine all rubber hoses and tubes departing from a tank. Check reliability of connections, existence on hoses of wear tracks, a perezhatiya and other damages. Especially carefully check a condition of ventilating tubes and hoses of a tank which often wind a mouth and are pressed or get littered. Track a condition of hoses on all their length, to a forward part of the car. Replace the damaged sites of pipelines.
4. If after checks the gasoline smell is still felt, then check system of catching of vapors (see subsection 2.23).