Toyota Land Cruiser

FJ60, FJ62 and FJ80 1980-1997 of release

Repair and operation of the car

Toyota Land Cruiser
+ 1. Maintenance instruction
+ 2. Maintenance
+ 3. Engines
+ 4. Cooling systems, heating
+ 5. Fuel and exhaust systems
+ 6. System of decrease in toxicity
+ 7. Transmission
+ 8. Brake system
+ 9. Suspension brackets and steering
+ 10. Body
- 11. Electric equipment
   11.1. Search of malfunctions
   11.2. Safety locks
   11.3. Fusible crossing points
   11.4. Breakers
   11.5. Relay
   11.6. Breaker of indexes of turn / alarm system
   11.7. A combination of switches on a steering column
   11.8. Lock of ignition and drum of the lock
   11.9. Indexes of level of fuel, pressure and temperature of oil
   11:10. Guard of devices
   11:11. Screen wiper electric motor
   11:12. Receiver and loudspeakers
   11:13. Antenna
   11:14. Heater of back glass
   11:15. Headlights
   11:16. Case of a halogen headlight
   11:17. Sound signal
   11:18. Replacement of lamps
   11:19. Side mirrors with the electric drive
   11:20. System cruise control
   11:21. Window regulator electric drive
   11:22. Electric drive of door locks
   11:23. Safety cushions
+ 12. Electrical circuitries

11:23. Safety cushions

GENERAL INFORMATION

Safety cushions (System of pneumosafety of SRS) are intended for protection of the driver (and the passenger) on a front seat in case of collision.

On a part of cars 2 pillows, one of which (from the driver) is mounted in the central part of a wheel, and another – on the right side of the forward panel of salon are provided. Also is a part of the system the block of sensors and management mounted on the center of the car.

THE SAFETY MODULE FROM THE DRIVER

The packed pillow and the device of forcing (reactor) which is under a pillow is a part of the module and it is connected to it an opening through which gas at receipt of a signal is supplied. The signal is given on the cable winded in a flexible spiral around a wheel shaft irrespective of a wheel angle of rotation. The pillow is inflated with the nitrogen which is formed as a result of reaction of an oxide of copper and azid of sodium.

THE SAFETY MODULE FROM THE PASSENGER

The device of forcing (reactor), the put pillow, the reactor and the facing panel enter into structure of the module located over a box for trifles. Passenger's pillow much more than driver's pillow. Exterior finish of a cover of a pillow coincides with finishing of the forward panel. The seam which breaks when forcing gas in a pillow is provided in a cover (gas is formed as a result of reaction of an oxide of iron and azid of sodium).

BLOCK OF THE SENSOR AND DIAGNOSTICS

The block provides food and operation of a safety cushion even at the switched-off battery. The block checks a condition of a security system. The control lamp of system (AIR-BAG lamp) at first lights up and at serviceable system dies away. If the system is faulty, then the lamp continues to burn or blink (or the sound signal is distributed). In this case the car should be handed over immediately in car service for check.

Prevention

To disconnect systems of pneumosafety.

The neglect precautionary measures leads to casual disclosure of a pillow and to severe injuries.

When performing any works near a steering column or any unit of system it is necessary to disconnect safety cushions. For this purpose execute the following:

  – expose wheels in the provision of driving on a straight line and transfer the ignition key to position of LOCK;
  – disconnect the battery from weight;
  – start works later not less than 90 sec., i.e. through time necessary for the category of the condenser.

At manipulations with a pillow container always you take the revetted side of a container in the direction from yourself. It is forbidden to put a container the revetted party down. It is forbidden to measure resistance of any unit of system of pneumosafety as operation of a pillow from the ohmmeter battery is possible.

Before performance of welding works disconnect the socket of a safety cushion of yellow color which is located under a steering column about the socket of a combination of switches (from the driver) or a box for trifles (from the passenger).

It is forbidden to throw out a container with a pillow.