Toyota Land Cruiser

FJ60, FJ62 and FJ80 1980-1997 of release

Repair and operation of the car



Toyota Land Cruiser
+ 1. Maintenance instruction
- 2. Maintenance
   2.1. Additional maintenance
   2.2. Technical characteristics
   2.3. An arrangement of units in a motor compartment
   2.4. Maintenance terms
   - 2.5. Check of level of liquids
      2.5.1. Oil level in the engine
      2.5.2. Cooling liquid
      2.5.3. Windshield washer liquid
      2.5.4. Electrolyte of the rechargeable battery
      2.5.5. Liquid of a hydraulic actuator of brakes and coupling
   2.6. Check of a condition of tires and pressure in tires
   2.7. Liquid level in automatic transmission
   2.8. Liquid level in system of a hydraulic actuator of steering
   2.9. Replacement of oil in the engine and an oil filter
   2.10. Check of a state and care of the battery
   2.11. Check of the cooling system
   2.12. Check and replacement of hoses in a motor compartment
   2.13. Check and replacement of brushes of screenwash
   2.14. Shift of wheels
   2.15. Check of a suspension bracket and steering
   2.16. Check of the exhaust system
   2.17. Check of level of oil in the manual transmission
   2.18. Check of level of oil in the transfer case
   2.19. Check of level of oil in reducers of bridges
   2.20. Check of a condition of seat belts
   2.21. Thermostat of the air filter (carburetor engines)
   2.22. Check and lubricant of the exhaust valve
   2.23. System of catching of vapors of gasoline
   2.24. Check of system of recirculation
   2.25. Air gate of the carburetor
   2.26. Zolotnik of system of ventilation of a case
   2.27. Check and replacement of the air filter
   2.28. Replacement of spark plugs
   2.29. Check and adjustment of gaps of valves
   2.30. Idling turns (carburetor engines)
   2.31. Drive belts
   2.32. Check of fuel system
   + 2.33. Check of brakes
   2.34. Check and adjustment of pedals of coupling (brake)
   2.35. Replacement of the fuel filter
   2.36. High-voltage wires, runner and covers of the distributor
   2.37. Check and installation of the moment of ignition
   2.38. Care of the cooling system
   2.39. Naves and bearings of forward wheels
   2.40. Replacement of liquid in automatic transmission and the filter
   2.41. Replacement of oil in the manual transmission
   2.42. Replacement of oil in the transfer case
   2.43. Replacement of oil in a back (forward) reducer
   2.44. Gaps in valves on the engine 1FZ-FE
+ 3. Engines
+ 4. Cooling systems, heating
+ 5. Fuel and exhaust systems
+ 6. System of decrease in toxicity
+ 7. Transmission
+ 8. Brake system
+ 9. Suspension brackets and steering
+ 10. Body
+ 11. Electric equipment
+ 12. Electrical circuitries




eeac64fe


2.5.5. Liquid of a hydraulic actuator of brakes and coupling

GENERAL INFORMATION

Determination of level of liquid in a nutritious tank of the main brake cylinder

Liquid level in a nutritious tank of the main brake cylinder is determined by the marks Min and Max.

Determination of level of liquid in a coupling cylinder tank

Level (1) of liquid in a tank of the cylinder of coupling prosmativatsya outside.

The main cylinder of brakes is mounted on the vacuum amplifier in a motor compartment. The main cylinder of coupling provided on cars from the manual transmission is near the main cylinder of brakes.

Liquid level in both tanks has to be 6 mm lower than the mark Max.

PERFORMANCE ORDER
1. If liquid level in both tanks is lower normal, then remove traffic jams from tanks, previously having wiped a surface of tanks with pure rags.
2. In tanks of the main cylinder of brakes and coupling add only the recommended liquid (see subsection 2.2). It is forbidden to add the liquid which was in an open vessel.
3. After removal of a stopper of a tank check existence of pollution in a tank. In the presence of a deposit liquid should be merged and replaced.
4. After restoration of level of liquid in tanks be convinced of reliability of fastening of traffic jams to avoid leak of liquid and (or) pressure drop in system.
5. Level of brake fluid will go down in process of natural wear of brake shoes. Need of a frequent dolivka of liquid in a tank of the main cylinder of brakes is a leak sign in the brake system which reason should be found and eliminated immediately. Check all connections and a condition of tubes and hoses of a brake contour, and also wheel cylinders and the vacuum amplifier.
6. If when checking level of liquid in a tank of the main brake cylinder absence is revealed (or almost total absence) liquids, then it is necessary to remove air from system.