Toyota Land Cruiser

FJ60, FJ62 and FJ80 1980-1997 of release

Repair and operation of the car



Toyota Land Cruiser
- 1. Maintenance instruction
   1.1. Introduction
   1.2. Control panel
   - 1.3. Governing bodies and instrumentations
      1.3.1. Keys
      1.3.2. System of an immobilizer (recognition of a code of launch of the engine)
      1.3.3. Doors
      1.3.4. Electric equipment of doors
      1.3.5. Headlights and indexes of turn
      1.3.6. Cleaners and washers of glasses
      1.3.7. Cowl latch
      1.3.8. Index of level of fuel
      1.3.9. Index of temperature of cooling liquid
      1.3.10. Voltmeter
      1.3.11. Tachometer
      1.3.12. The counter of the total passable way
      1.3.13. Indexes and the warning signals
      1.3.14. Blocking of differential
   1.4. Identification numbers of the car
   1.5. Purchase of the old car or mysterious set of figures and letters
   1.6. The changed numbers
   1.7. Arrangement of elements
+ 2. Maintenance
+ 3. Engines
+ 4. Cooling systems, heating
+ 5. Fuel and exhaust systems
+ 6. System of decrease in toxicity
+ 7. Transmission
+ 8. Brake system
+ 9. Suspension brackets and steering
+ 10. Body
+ 11. Electric equipment
+ 12. Electrical circuitries




eeac64fe


1.3.13. Indexes and the warning signals

GENERAL INFORMATION

At inclusion of the following light indexes or a sound signal arrive as follows:

If the car is removed from the emergency brake, then stop and check.
Stop and check.
Stop and check.
Address in a workshop of car service of the dealer.
The control lamp of a reserve of fuel burns Fill a tank.
Address in a workshop of car service of the dealer.
Close all doors (including back).
Immediately address in a workshop of car service of the dealer.
Merge water.
The reminding sound signal Switch off headlights.

Light index of malfunction of brakes

Reminds of need to release the emergency brake.

Make sure that the car is completely removed from the emergency brake. After removal the index dies away.

Low level of liquid in a nutritious tank of brakes or low depression (on cars with the diesel).

If the index lights up and does not die away at the movement, reduce speed and smoothly stop on a roadside. Sharply you do not brake. Fire of a lamp testifies to malfunction of brakes. Check liquid level in a nutritious tank which is visible through a transparent wall.

Make sure that the car is completely removed from the emergency brake.

If the level of brake fluid fell:

Check work of brakes in the safe place. If brakes work regularly so far, then, carefully conducting the car, reach the nearest service of car service or car repair shop.

If brakes are faulty, then tow off the car in repair.


Prevention

It is dangerous to continue the movement with the low level of brake fluid.


If the level of brake fluid is normal:

CARS WITH THE PETROL ENGINE

Check a condition of system of the alarm system, having addressed to service of car service.

CARS WITH THE DIESEL ENGINE

In these cars the system of the alarm system or the vacuum amplifier of brakes can be faulty.

Check a condition of system of the alarm system and vacuum amplifier of brakes, having addressed to service of car service.

The car at such malfunctions needs towage.

The control lamp of the category of the battery burns

Inclusion of this index demonstrates that the battery is discharged. If the lamp lights up during the movement, then the system of a charge of the battery is faulty.

The system of ignition of the engine will continue to work to the full category of the battery. Switch off the conditioner, the receiver, the fan, etc., ask for the help on the nearest car repair shop.


Prevention

The movement with the torn-off or weakened drive belt is forbidden.


The control lamp of emergency pressure of oil burns

Inclusion of this index testifies to oil pressure in the engine below norm.

If the lamp lit up during the movement, then, having reduced speed, stop on a roadside, immediately stop the engine. Call service of car service of the dealer or on the nearest car repair shop, ask for the help.

The control lamp of emergency pressure of oil can light up and die away during the operation of the engine idling or light up at sharp braking by the engine. If the lamp dies away by weak pressing a pedal of a butterfly valve, then to worry there is nothing.

The lamp of emergency pressure of oil can light up at too low level of oil in the engine. However on fire of a lamp it is impossible to judge the oil level which is checked only by the probe.

Remark. The movement at fire of control Pampas of emergency pressure of oil is forbidden. This malfunction does not reduce traffic safety, but the engine will fail.

The control lamp of failure of the system of electric equipment of the engine burns (for engines of types 4E-FE, 4A-FE, 7A-FE)

If this lamp lit up during the movement, then as soon as possible address to service of car service of the dealer or on the nearest car repair shop for check or repair.

The control lamp of a reserve of fuel burns

The lamp lights up at almost empty tank. Fill a tank as soon as possible.

The control lamp of ABS burns

Fire of this lamp indicates malfunction in system of anti-blocking of brakes. If this lamp lit up during the movement, then as soon as possible address to service of car service of the dealer.

The lamp lights up at turn of the ignition key in situation On, but later 3 with a lamp has to go out.

If this lamp lights up, and the index of malfunction of brakes does not burn, then the brake system is serviceable, but works without unblocking of wheels when braking.

The control lamp signaling about leaky closed door burns

The lamp dies away after reliable closing of doors of salon and a back door.

Light index of critical condition of an additional security system

This index lights up at turn of the ignition key in the provision of ASS or On. Later 6 with illumination of the index dies away. It means serviceability of an additional security system (system of inflatable pillows).

At simultaneous existence of any of two states provided below illumination of the light index of critical condition of an additional security system lights up that testifies to malfunction of the touch device of the inflatable device of a pillow, break in a chain and to other malfunctions. In this case it is necessary to address to service of car service immediately.

At turn of the ignition key in the provision of ASS or On the index does not light up or, on the contrary, continues to shine constantly.

The index lights up during the movement.

The control lamp of the filter of fuel system burns (for cars with the diesel engine)

It indicates a congestion in the filter of the excess of the condensed moisture which reached the set level.

At fire of a lamp of the filter immediately merge water.


Prevention

The movement after operation of the alarm system of the fuel filter is forbidden, at long driving at a congestion of moisture the fuel pump of system of injection of fuel will fail.


Sound signal

The sound signal will work if the door from the driver is open, the ignition key is turned in position of LOCK and headlights are included. If to get a key from the lock, then the signal will not disappear until headlights are included.

Verification of the indexes reminding of need of service (except for a control lamp of a reserve of fuel)

PERFORMANCE ORDER
1. Put the car on the emergency brake.
2. Open one of side doors or a back door.
3. Close a door. The control lamp has to go out.
4. Turn the ignition key in the provision of ASSORTMENT. The light index of safety cushions has to light up and later 6 with to go out.
5. Turn the ignition key in situation On, do not start the engine. All mnemonic light indexes except for a control lamp of a reserve of fuel and the light index of safety cushions have to light up. The control lamp of system of anti-blocking has to go out later 3 pages.
6. If at least one of light indexes does not work as it is described above, then or the lamp fused, or the scheme of the alarm system needs under repair. Immediately address to service of car service.